2004 Ford Escape XLS 4x4 Automatic

Recall Summary

Ford Motor Company (Ford) Is Recalling Certain Model Year 2001-2008 Ford Escape And Mercury Mariner Vehicles Manufactured March 31, 2001, To September 1, 2009. The Affected Vehicles Are Equipped With Either A 2.3L Or 3.0L Engine And Have Had Their Cd4E Transmission Replaced With Remanufactured One That Was Rebuilt Between June 11, 2015 Through July 15, 2015. These Service Repair Part Transmissions Have A Shift Lever Bolt That May Not Be Properly Tightened. As A Result, The Shift Control Lever Could Disengage From The Transmission Without Warning.

Recall Consequences

If The Shift Lever Disengages From The Transmission, A Driver May Be Unable To Shift Gear Positions And The Indicated Shift Position May Not Represent The Gear Position The Vehicle Is In. Should A Disengagement Occur While The Vehicle Is Being Driven, When The Driver Goes To Stop And Park The Vehicle, The Gear Selection Indicator May Show That The Transmission Is In The "Park" Position, But The Vehicle Transmission May Not Actually Be In The "Park" Gear Position. If The Vehicle Is Not In The "Park" Position There Is A Risk The Vehicle Will Roll Away As The Driver And Other Occupants Exit The Vehicle Or Anytime Thereafter. A Vehicle Rollaway Increases The Risk Of Injury To Exiting Occupants And Bystanders.

Recall Remedy

Ford Will Notify Owners, And Dealers Will Inspect The Transmissions And Either Tighten The Manual Shift Lever Bolt Or Replace The Manual Shift Lever Assembly. These Repairs Will Be Performed Free Of Charge. The Recall Began On October 23, 2015. Owners May Contact Ford Customer Service At 1-866-436-7332. Ford'S Number For This Recall Is 15S28.

Recall Summary

The Timken Company (Timken) Is Recalling Certain Aftermarket Front Wheel Bearings, Part Number 510072, Sold From January 22, 2015, To May 21, 2015, To Be Used As Service Parts On 2001-2012 Ford Escape, 2001-2011 Mazda Tribute, And 2005-2011 Mercury Mariner Vehicles. The Affected Wheel Bearings Have Incorrect Dimensions Of A 42Mm Bore, 76Mm Outer Dimension, And 39Mm Width, Instead Of A 42Mm Bore, 78Mm Outer Dimension And A 45Mm Width.

Recall Consequences

Use Of An Incorrectly Sized Wheel Bearing Can Adversely Affect The Braking And Steering Of The Vehicle, Increasing The Risk Of A Crash.

Recall Remedy

Timken Has Begun Notifying Distributors Who Will Offer Purchasers Replacement Wheel Bearings, Free Of Charge. The Recall Began On May 21, 2015. Owners May Contact Timken Customer Service At 1-866-984-6536.

Recall Summary

Ford Motor Company (Ford) Is Recalling Certain Model Year 2001-2004 Escape Vehicles Manufactured October 22, 1999, Through January 23, 2004, Originally Sold, Or Currently Registered In, Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin And The District Of Columbia. These Vehicles May Experience Excessive Corrosion At The Forward Attachment Of The Lower Control Arm.

Recall Consequences

A Separation Of The Lower Control Arm Can Result In A Significant Loss Of Steering Control, Increasing The Risk Of A Crash.

Recall Remedy

Ford Will Notify Owners, And Dealers Will Install A Newly Designed Reinforcement Cross-Brace, Free Of Charge. The Recall Began On May 30, 2014. Owners May Contact Ford At 1-800-392-3673. Ford'S Number For This Recall Is 14S02.

Recall Summary

Ford Motor Company Is Recalling Certain Model Year 2001 Through 2004 Escape Vehicles Equipped With 3.0L V6 Engines And Speed Control Manufactured From October 22, 1999, Through January 23, 2004. Inadequate Clearance Between The Engine Cover And The Speed Control Cable Connector Could Result In A Stuck Throttle When The Accelerator Pedal Is Fully Or Almost-Fully Depressed. This Risk Exists Regardless Of Whether Or Not Speed Control (Cruise Control) Is Used.

Recall Consequences

A Stuck Throttle May Result In Very High Vehicle Speeds And Make It Difficult To Stop Or Slow The Vehicle, Which Could Cause A Crash, Serious Injury Or Death.

Recall Remedy

Ford Will Notify Owners, And Dealers Will Repair The Vehicles By Increasing The Engine Cover Clearance, Free Of Charge. The Safety Recall Began August 3, 2012. Remedy Parts Are Expected To Be Available In Mid-August 2012. Until Then Dealers Will Disconnect The Speed Control Cable As An Interim Remedy, If Parts Are Not Available At The Time Of An Owner'S Service Appointment. Owners May Contact Ford At 1-866-436-7332.

Recall Summary

On Certain Sport Utility Vehicles Equipped With Antilock Brakes (Abs), The Abs Module Connector May Have Missing Or Dislodged Wire Seals. This Condition Could Allow Contamination To Enter The Module Connector, Creating A Potential For An Electrical Short.

Recall Consequences

An Electrical Short Might Cause An Abs Malfunction That Would Illuminate The Abs Warning Light, And In Some Cases, The Module May Overheat Resulting In Burning Odor, Smoke, And/Or Fire. This Condition Could Occur Either When The Vehicle Ignition Switch Is In The Off Position Or While The Vehicle Is Being Operated.

Recall Remedy

Dealers Will Inspect The Wire Harness Connector To The Abs Module For Missing Or Dislodged Wire Seals, And Repair Or Replace The Harness Connector As Appropriate. The Dealer Will Also Inspect The Connector On The Abs Module And Replace It If It Is Found To Be Corroded Or Damaged. The Recall Began On April 23, 2007. Owners May Contact Ford At 1-800-392-3673.

Recall Summary

Certain Cardone Master Cylinders With Part Numbers 10-2925, 10-2987, 10-2987Mza, 10-3083, 11-3015, 11-3042, 11-3044, 11-3045, 11-3047, 11-3064, And 11-3156, And With Date Codes Lower Than Dca7078 Sold As Replacement Equipment For Use On The Vehicles Listed Above. The Seal On Master Cylinder Can Fail And Leak Brake Fluid.

Recall Consequences

Loss Of Brake Fluid Can Result In Poor Braking Performance, Possibly Resulting In A Vehicle Crash.

Recall Remedy

Cardone Will Notify Owners And Offer To Repurchase Any Defective Master Cylinders. The Recall Began During April 2007. Owners Can Contact Cardone At 1-800-777-4780.

Recall Summary

Certain 2004-2005 Sport Utility Vehicles And Certain 2001-2003 Sport Utiity Vehicle Having Rear Liftgate Components Serviced With 2004 Equivalent Components Fail To Comply With The Requirements Of Federal Motor Vehicle Safety Standard No. 206, 'Door Locks And Door Retention Components.' The Rear Liftgate Latching System Does Not Meet The Inertia Load Requirement In One Direction.

Recall Consequences

If The Liftgate Is Left Unlocked, There Is The Potential That It May Open During A Crash.

Recall Remedy

Dealers Will Replace The Rear Liftgate Latch Release Rod, The Release Rod Attachment Clip And The Door Handle Return Spring. The Recall Began On March 31, 2005. Owners Should Contact Ford At 1-800-392-3673.

Recall Summary

On Certain Sport Utility Vehicles Built With 3.0L V6 Engines, The Accelerator Cable May Prevent The Throttle From Returning To The Idle Position.

Recall Consequences

An Unexpected Increase In Engine Idle Speed May Increase Stopping Distance And May Result In A Vehicle Crash.

Recall Remedy

Dealers Will Replace The Accelerator Cable. The Recall Began On January 10, 2005. Owners Should Contact Ford At 1-866-436-7332.

Recall Summary

Recall Consequences

Recall Remedy

Recall Summary

Recall Consequences

Recall Remedy

Recall Summary

Recall Consequences

Recall Remedy

Recall Summary

Recall Consequences

Recall Remedy

Recall Summary

Recall Consequences

Recall Remedy

Recall Summary

Recall Consequences

Recall Remedy

Recall Summary

Recall Consequences

Recall Remedy